| MATERIAL SAFETY DATA SHEET | ||||
SECTION I |
||||
| EMERGENCY TELEPHONE NO. | ||||
| CHEMTREC 1-800-424-9300 | ||||
| PRODUCT NAME: Qualiti Laboratories Kleenzyme | ||||
| DATE PREPARED: 12-25-09 | ||||
| HAZARD RATING: HEALTH-2; FIRE-0; REACTIVITY-0; SPECIAL-NONE | ||||
| (HAZARD RATING SCALE: 4-SEVERE; 3-SERIOUS; 2-MODERATE; 1-SLIGHT; 0-MINIMAL) | ||||
SECTION II – HAZARDOUS INGREDIENT/IDENTITY INFORMATION |
||||
| NAME | OSHA PEL | ACGIH TLV | OTHER | % |
| Nonylphenol Ethoxlate | ne | ne | ne | 2.00 |
| CAS No. 26027-38-3 | ||||
| Propylene Glycol | ne | ne | ne | 30.00 |
| CAS No. 57-55-6 | ||||
| Ne = not established | This product does not contain substances subject to Section 313 of SARA Title III. | |||
SECTION III – PHYSICAL/CHEMICAL CHARACTERISTICS |
||||
| BOILING POINT: | >212 degrees F | |||
| VAPOR PRESSURE: | Not determined | |||
| VAPOR DENSITY (Air=1): | Not determined | |||
| SPECIFIC GRAVITY (H2O=1): | 1.043 | |||
| MELTING POINT: | n/a | |||
| EVAPORATION RATE: | Unknown | |||
| SOLUBILITY IN WATER: | Appreciable | |||
| APPEARANCE AND ODOR: | Clear liquid; mint odor | |||
SECTION IV – FIRE AND EXPLOSION HAZARD DATA |
||||
| FLASH POINT: | Unknown | |||
| EXTINGUISHING MEDIA: | Dry chemical, carbon dioxide, foam, or water fog. | |||
| FIRE FIGHTING PROCEDURES: | Fire fighters should wear self-contained breathing apparatus & protective clothing when fighting chemical fires. | |||
| FIRE & EXPLOSION HAZARDS: | None known | |||
SECTION V – REACTIVITY DATA |
||||
| STABILITY: | Stable | |||
| CONDITIONS TO AVOID: | Extreme heat | |||
| INCOMPATABILITY: | Strong oxidizing agents | |||
| HAZARDOUS DECOMPOSITION: | Nitrous oxides and ammoniacal vapors; oxides of carbon | |||
| HAZARDOUS POLYMERIZATION: | Will not occur | |||
SECTION VI – HEALTH HAZARD DATA |
||||
| ROUTE OF ENTRY: | INHALATION? Yes | |||
| SKIN? Yes | ||||
| INGESTION? Unlikely | ||||
| HEALTH HAZARDS: | ||||
| Contact with skin and eyes may cause irritation. Inhalation can cause irritation of nasal and respiratory passages. Ingestion may cause gastrointestinal irritation. | ||||
| CARCONOGENICITY: | NTP? n/a | |||
| IARC MOHOGRAPHS? n/a | ||||
| OSHA REGULATED? n/a | ||||
| SIGNS AND SYMPTOMS OF EXPOSURE: | ||||
| Redness, tearing and pain may result from eye contact. Skin contact may cause redness and irritation. Ingestion may cause nausea, vomiting, and diarrhea. | ||||
| MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: | ||||
| Bacterial infection may occur through open wounds or broken skin. Overexposure to components of this material has apparently been found to cause liver abnormalities and kidney damage in laboratory animals. | ||||
| EMERGENCY AND FIRST AID PROCEDURES: | ||||
| Flush eyes with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical attention. Avoid contact with open wounds or broken skin. In case of skin contact, was area with soap and water and apply a topical antiseptic agent. In case of ingestion, give affected person several glasses of water and induce vomiting. Obtain medical attention. Never give anything by mouth to an unconscious person. | ||||
SECTION VII – PRECAUTIONS FOR SAFE HANDLING AND USE |
||||
| STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: | ||||
| Wear eye protection and rubber gloves. Contain all spills and leaks to prevent discharge into the environment. For small spills soak up with absorbent, shovel into waste container, flush area with water. For large spills recover liquid for reprocessing or disposal. | ||||
| WASTE DISPOSAL METHOD: | ||||
| Dispose of in accordance with all Local, State and Federal regulations. | ||||
| PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: | ||||
| Store in a cool dry place. Keep container tightly closed when not in use. To maintain biological properties, do not freeze and do not store above 100 degrees F. Keep out of reach of children. | ||||
| OTHER PRECAUTIONS: | ||||
| This product may contain a trace amount of one or more of the chemicals on the California list of known carcinogens or substances known to cause birth defects or other reproductive harm. These are not added to the product but occur naturally in the raw materials or processing equipment. | ||||
SECTION VIII – CONTROL MEASURES |
||||
| RESPIRATORY PROTECTION: | Not required under normal conditions of use | |||
| VENTILATION: | Natural | |||
| PROTECTIVE GLOVES: | Rubber or vinyl gloves | |||
| EYE PROTECTION: | Chemical goggles or glasses | |||
| OTHER PROTECTION: | Wear protective clothing to prevent repeated or prolonged contact. Eye wash station and safety shower should be near work area. | |||
| WORK/HYGIENIC PRACTICES: | Wash and dry hands thoroughly after handling. | |||